journals for ggbs with quarry sand

  • A STUDY ON PARTIAL REPLACEMENT OF CEMENT WITH

    replacement of natural sand by quarry sand and 1.5 % dosage of mixture. Split tensile strength of concrete, when cement is replaced with 40% of GGBS & 60% of quarry dust for maximum dosage of mixture.Flexural strength will be max, if 30% of cement by GGBS & 60% of quarry sand as constant replacement for fine aggregates.

  • An Experimental Study on Partial Replacement of Cement by ...

    An Experimental Study on Partial Replacement of Cement by Ggbs and Natural Sand by Quarry Sand in Concrete Chaithra H L1, Pramod K2, Dr. Chandrashekar A3 1PG Student, Dept of Civil Engineering, K V G College of Engineering, Sullia, India 2Assistant Professor, Dept of Civil Engineering, K V G College of Engineering, Sullia, India 3HOD, Dept. of Civil Engineering, K VG College of Engineering ...

  • Effect of Simultaneous Replacement of Cement with Ground ...

    Feb 15, 2017 · Further increase in replacement of GGBS and Quarry dust there is a decrease in strength from Table-13. This shows that 20% replacement of cement and fine aggregate with GGBS and Quarry dust shows better results. The proportion of GGBS and Quarry dust that would result in maximum strength of concrete is 10% and 20% respectively.

  • Partial Replacement of Fine Aggregate with GGBS

    4. Sonali K. Gadpalliwar, R. S. Deotale, Abhijeet R. Narde , “To Study the Partial Replacement of Cement by GGBS & RHA and Natural Sand by Quarry Sand In Concrete”, IOSR Journal of Mechanical and Civil Engineering (IOSR-JMCE), Volume 11, Issue 2 Ver. II (Mar- Apr. 2014), Pg. No. 69-77. 5.

  • Strength and Corrosion Resistance Properties of Ggbs ...

    The experimental study undertaken to investigate the influence of partial replacement of cement with ground granulated blast furnace slag (GGBFS) in concrete containing quarry dust as fine aggregate. Tests were conducted to determine the optimum level of

  • MECHANICAL BEHAVIOUR OF CONCRETE MADE WITH

    different percentages of GGBS with 100% natural sand and 50% quarry dust. Table 7 flexural strength of M20 concrete over different percentages of GGBS with natural sand and 50% quarry dust S.no % of GGBS 100% natural sand 50% quarry dust 1 20 3.64 3.48 2 30 3.84 3.54 3 40 3.59 3.42 4 50 3.45 3.19 5 60 3.89 3.62 Figure4 flexural strength o f ...

  • Journal of Chemical and Pharmaceutical Sciences ISSN: 0974 ...

    tensile strength for M40 grade of concrete mixes when 10% GGBS + 10% Metakaolin is replaced with 30% Quarry sand concrete. Hence, the combination of Metakaolin and GGBS with quarry sand concrete will be effective and can be safely used to increase the strength of concrete. KEY WORDS: High performance concrete, Metakaolin, GGBS, Quarry sand ...

  • (PDF) Suitability of GGBFS & RHA (Combined) as Source ...

    Sonali K. Gapalliwar, ‘To Study the Partial Replacement of Cement by GGBS & RHA and Natural Sand by Quarry Sand in Concrete’ IOSR Journal of Mechanical and Civil Engineering (IOSR-JMCE) e-ISSN: 2278-1684,p-ISSN: 2320-334X, Volume 11, Issue 2 Ver. II (Mar- Apr. 2014), PP 69-77 [9] T. Ravi Prasad, International Journal of Academic Research ...

  • International Journal of Technical Innovation in Modern ...

    International Journal of Technical Innovation in Modern Engineering & Science (IJTIMES) Impact Factor: 5.22 (SJIF-2017), e-ISSN: 2455-2585 ... Rather than sand, Quarry dust is employed that is partly replaced by fly ash to boost the strength to weight quantitative relation. ... The already combined cement and GGBS/Quarry dust was placed over ...

  • STUDY ON PROPERTIES OF CONCRETE WITH MANUFACTURED

    Sand. International Journal of Civil Engineering ... concrete with GGBS and Robo sand . ... in the reports published on the use of this kind of M-sand and quarry dust by other ...

  • Partial Replacement of Quarry Dust and Cement with Ground ...

    to replace the sand. Quarry dust the option to replace the sand. Thus, we have studied the replacement of cement with GGBS and sand with Quarry dust. Ground-granulated blast- (GGBS or GGBFS) is a obtained by quenching molten iron slag (a by-product of iron and steel making) from a blast furnace in water or steam, to

  • MECHANICAL BEHAVIOUR OF CONCRETE MADE WITH

    different percentages of GGBS with 100% natural sand and 50% quarry dust. Table 7 flexural strength of M20 concrete over different percentages of GGBS with natural sand and 50% quarry dust S.no % of GGBS 100% natural sand 50% quarry dust 1 20 3.64 3.48 2 30 3.84 3.54 3 40 3.59 3.42 4 50 3.45 3.19 5 60 3.89 3.62 Figure4 flexural strength o f ...

  • Indian Journal of Science and Technology, DOI: 10.17485 ...

    Abstract Objective: This study mainly focused on use of quarry dust on replaced with river sand for making geopolymer bricks and paver blocks. Method: Investigations were done on usage of eco-friendly Geopolymer Concretes in lieu of OPC concrete for producing geopolymer bricks and paver blocks. Fly ash, GGBS, aggregates and pellet form of sodium hydroxide were mixed

  • An Experimental Investigation on Properties of Concrete by ...

    as a replacement of Natural Sand due to its scarcity. The replacement percentages of Cement with GGBS are 20%, 40% and 60% by weight and 25%, 50%, 75% and 100% of Quarry Dust are used as a replacement of Natural Sand. Various combinations of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.

  • Journal of Chemical and Pharmaceutical Sciences ISSN: 0974 ...

    tensile strength for M40 grade of concrete mixes when 10% GGBS + 10% Metakaolin is replaced with 30% Quarry sand concrete. Hence, the combination of Metakaolin and GGBS with quarry sand concrete will be effective and can be safely used to increase the strength of concrete. KEY WORDS: High performance concrete, Metakaolin, GGBS, Quarry sand ...

  • THE EFFECT OF QUARRY DUST WITH CEMENT BY ... - journals

    Nov 19, 2018 · Hence, partial replacement of cement becomes a necessity as well as natural sand in concrete by waste material or by-product without compromising the quality of the end product. Partial replacement with Ground Granulated Blast furnace Slag (GGBS), Fly Ash (PFA), Silica Fumes (SILICA) incorporates with 100% of Quarry Dust (QD) as sand replacement.

  • (PDF) High performance concrete with GGBS and ROBO sand

    From the experimental results 50% of cement can be replaced with GGBS. 6. The percentage increase of compressive st rength of concrete is 11.06 a nd 17.6% at the age of 7 and 2 8 days. by ...

  • (PDF) A Study on Stabilization of Expansive Soil with ...

    IOSR Journal of Mechanical and Civil Engineering (IOSR-JMCE) e-ISSN: 2278-1684,p-ISSN: 2320-334X, Volume 15, Issue 4 Ver. III (Jul. - Aug. 2018), PP 41-46 iosrjournals.org A Study on Stabilization of Expansive Soil with Ground Granulated Blast Furnace Slag and Flash 4 S. Ammireddy1, K.Sridevi2, Ch.Sivanarayana3, Dr. D S V Prasad 1 (M.Tech Student, Department of Civil Engineering,

  • Experimental investigation on concrete subjected to direct ...

    Dec 14, 2021 · Fine aggregates is fine materials which can be of sand or finely crushed rock materials,these occupy 60% to 75% of the total concrete’s volume. Fine aggregate should be clean and hard and should be chemical free to obtain good concrete mix. 2.4. Ground Granulated Blast Furnace Slag (GGBS) GGBS is abbreviated as Ground Granulated Blast Furnace ...

  • journals on quarry dust - affittileccecentro.it

    Journals For Replacement Of Sand By Quarry Dust In Concrete Quarry dust as partial replacement material for sand in journal indexing open access journal about ijser ijser is an online international open access peer review scholarly journal published monthly indexing is an important part of journal indexed content at the article level also provide doi for the articles ijser associated with ....

  • COMPARATIVE STUDY ON COST EFFECTIVE GEOPOLYMER

    geopolymer bricks made with quarry dust have attained less compressive strength when compared to geopolymer bricks made with sand. Key Words: Geopolymer, Fly ash, GGBS, Quarry dust, Sand, Compressive strength, Cost analysis 1.INTRODUCTION Bricks have been used in India for more than 1000 years. Due to the cost reduction as well as their less weight

  • THE DEVELOPMENT OF HIGH PERFORMANCED CONCRETE

    To study the properties of concrete by using GGBS and quarry sand. NOVATEUR PUBLICATIONS International Journal Of Research Publications In Engineering And Technology [IJRPET] ISSN: 2454-7875 VOLUME 2, ISSUE 12, Dec. -2016 34 | P a g e To study the properties of concrete. Mix Proportions for M 35 Grade Concrete

  • (PDF) Study of Partial Replacement of the Cement by GGBS ...

    International Research Journal of Engineering and Technology (IRJET) e-ISSN: 2395 -0056 Volume: 04 Issue: 03 | Mar -2017 irjet.net p-ISSN: 2395-0072 Study of Partial Replacement of the Cement by GGBS & RHA and Natural Sand by Quarry Sand in Concrete Snehal C. Mokashi #1, S. N. Daule #2 #1 M.E.Student,(Structural Engineering) Department of Civil Engineering, Dr.Vithalrao Vikhe Patil College ...

  • Utilisation of dewatered extracted soil in concrete blocks ...

    Dec 01, 2021 · The 42.5 # OPC in accordance with GB 175 and S95 GGBS in accordance with GB/T 18046 were used as the binders. Their chemical compositions and particle distributions are shown in Table 1 and Fig. 2, respectively. The median particle sizes (D50) of the OPC, GGBS and soil are 22.013 µm, 12.279 µm, and 23.502 µm, respectively.

  • Partial Replacement of Fine Aggregate with GGBS

    , “To Study the Partial Replacement of Cement by GGBS & RHA and Natural Sand by Quarry Sand In Concrete”, IOSR Journal of Mechanical and Civil Engineering (IOSR-JMCE), Volume 11, Issue 2 Ver. II (Mar- Apr. 2014), Pg. No. 69-77. [5] A.H.L.Swaroop, K.Venkateswararao, Prof P Kodandaramarao, ―“Durability Studies On Concrete

  • Partially Replacement of Fine Aggregate with GGBS

    (GGBS) in cement concrete as a sand substitute, for reducing the environmental problems related to the fine aggregate mining and waste disposal of slag. The percentage of GGBS replacement is 0,5,10 and 15 % to natural sand for the standard w/c ratio of 0.4 is considered. The extended work is done with 100%

  • An Experimental Investigation on Properties of Concrete by ...

    as a replacement of Natural Sand due to its scarcity. The replacement percentages of Cement with GGBS are 20%, 40% and 60% by weight and 25%, 50%, 75% and 100% of Quarry Dust are used as a replacement of Natural Sand. Various combinations of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.

  • International Journal of Science and Research (IJSR)

    Dec 12, 2017 · The replacement percentages of Cement with GGBS are 20 %, 40 % and 60 % by weight and 25 %, 50 %, 75 % and 100 % of Quarry Dust are used as a replacement of Natural Sand. Various combination of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.

  • Experimental Investigation on Workability of Concrete with ...

    To overcome from this crisis, partial replacement of Cement with GGBS, natural sand with quarry sand (QS) can be an economic Alternative. The cubes are tested for compressive strengths. Ordinary Portland cement was partially replaced by GGBS of 0%, 30%, 40%, 50% and natural sand replacement by QS 0%, 40%, 50%, 60%.

  • An experimental investigation on the properties of ...

    of quarry waste fine aggregate in concrete mixtures. Misra ... Tensile Strength of Normal Concrete with GGBS 5.3. Normal Concrete with Robo Sand Sand was replaced with the Robo Sand in different proportions such as 25, 50, 75 & 100%. ... International Journal of Applied Research Sand

  • THE EFFECT OF QUARRY DUST WITH CEMENT BY ... - journals

    Nov 19, 2018 · Hence, partial replacement of cement becomes a necessity as well as natural sand in concrete by waste material or by-product without compromising the quality of the end product. Partial replacement with Ground Granulated Blast furnace Slag (GGBS), Fly Ash (PFA), Silica Fumes (SILICA) incorporates with 100% of Quarry Dust (QD) as sand replacement.

  • Study on Compressive Strength of Quarry Dust as Fine ...

    Jul 28, 2016 · The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

  • journals on quarry dust - affittileccecentro.it

    Journals For Replacement Of Sand By Quarry Dust In Concrete Quarry dust as partial replacement material for sand in journal indexing open access journal about ijser ijser is an online international open access peer review scholarly journal published monthly indexing is an important part of journal indexed content at the article level also provide doi for the articles ijser associated with ....

  • Experimental investigation on concrete subjected to direct ...

    Dec 14, 2021 · Fine aggregates is fine materials which can be of sand or finely crushed rock materials,these occupy 60% to 75% of the total concrete’s volume. Fine aggregate should be clean and hard and should be chemical free to obtain good concrete mix. 2.4. Ground Granulated Blast Furnace Slag (GGBS) GGBS is abbreviated as Ground Granulated Blast Furnace ...

  • COMPARATIVE STUDY ON COST EFFECTIVE GEOPOLYMER

    geopolymer bricks made with quarry dust have attained less compressive strength when compared to geopolymer bricks made with sand. Key Words: Geopolymer, Fly ash, GGBS, Quarry dust, Sand, Compressive strength, Cost analysis 1.INTRODUCTION Bricks have been used in India for more than 1000 years. Due to the cost reduction as well as their less weight

  • Volume 10, Issue 6, June 2021

    Manufactured sand, produced from granite stone, has been used as an alternative to fine aggregate that 50% replaces the river sand which is far superior to river sand in all aspects. This project work is to determine the material properties of cement, GGBS, aggregates

  • Experimental Study on the Performance and Microstructure ...

    Oct 18, 2016 · The dune sand, GGBS, cement, and gypsum were initially mixed dry in a mixer for about 2 minutes until they were homogenous throughout. Then, the entire amount of mixing water with the SP was added and the mixing process lasted for another 3 minutes, leading to